Photo: Eduardo Soares/Unsplash
- If newfangled meat alternatives can fill a large part of our demand, they might offer carnivores a way to reduce the environmental impact of their dining choices.
- There’s no question that today’s meat industry is bad for the planet. Livestock account for about 15% of global greenhouse gas emissions both directly and indirectly.
- Worse yet, the UN projects that global demand for meat will swell by 15% by 2031 as the world’s increasing population seeks more meat on their plates.
- Independent researchers have found that the average greenhouse gas footprint from plant-based meats was just 7% of beef for an equivalent amount of protein.
- Of course, how green plant-based meats actually are depends on the farming practices that underlie them.
If you’re an environmentally aware meat-eater, you probably carry at least a little guilt to the dinner table. The meat on our plates comes at a significant environmental cost through deforestation, greenhouse gas emissions, and air and water pollution – an uncomfortable reality, given the world’s urgent need to deal with climate change.
That’s a big reason there’s such a buzz today around a newcomer to supermarket shelves and burger-joint menus: products that look like real meat but are made entirely without animal ingredients. Unlike the bean- or grain-based veggie burgers of past decades, these “plant-based meats,” the best known of which are Impossible Burger and Beyond Meat, are marketed heavily toward traditional meat-eaters. They claim to replicate the taste and texture of real ground meat at a fraction of the environmental cost.
If these newfangled meat alternatives can fill a large part of our demand for meat – and if they’re as green as they claim, which is not easy to verify independently – they might offer carnivores a way to reduce the environmental impact of their dining choices without giving up their favorite recipes.
That could be a game-changer, some think. “People have been educated a long time on the harms of animal agriculture, yet the percentage of vegans and vegetarians generally remains low,” says Elliot Swartz, a scientist with the Good Food Institute, an international nonprofit organisation that supports the development of alternatives to meat. “Rather than forcing people to make behavior changes, we think it will be more effective to substitute products into their diets where they don’t have to make a behavior switch.”
There’s no question that today’s meat industry is bad for the planet. Livestock account for about 15% of global greenhouse gas emissions both directly (from methane burped out by cattle and other grazing animals and released by manure from feedlots and pig and chicken barns) and indirectly (largely from fossil fuels used to grow feed crops). Indeed, if the globe’s cattle were a country, their greenhouse gas emissions alone would rank second in the world, trailing only China.
Worse yet, the UN projects that global demand for meat will swell by 15% by 2031 as the world’s increasing – and increasingly affluent – population seeks more meat on their plates. That means more methane emissions and expansion of pastureland and cropland into formerly forested areas such as the Amazon – deforestation that threatens biodiversity and contributes further to emissions.
Not all kinds of meat animals contribute equally to the problem, however. Grazing animals such as cattle, sheep and goats have a far larger greenhouse gas footprint than non-grazers such as pigs and chickens. In large part that’s because only the former burp methane, which happens as gut microbes digest the cellulose in grasses and other forage.
Pigs and chickens are also much more efficient at converting feed into edible flesh: Chickens need less than two pounds of feed, and pigs need roughly three to five pounds, to put on a pound of body weight. (The rest goes to the energy costs of daily life: circulating blood, moving around, keeping warm, fighting germs and the like.) Compare that to the six to 10 pounds of feed per pound of cow.
As a result, the greenhouse gas emissions of beef cattle per pound of meat are more than six times those of pigs and nearly nine times those of chicken. (Paradoxically, grass-fed cattle – often thought of as a greener alternative to feedlot beef – are actually bigger climate sinners, because grass-fed animals mature more slowly and thus spend more months burping methane.)
Building fake meat
Plant-based meats aim to improve on that dismal environmental performance. Stanford University biochemist Pat Brown, for example, founded Impossible Foods after asking himself what single step he could take to make the biggest difference environmentally. His answer: Replace meat.
To do that, Impossible and its competitors basically deconstruct meat into its component parts, then build an equivalent product from plant-based ingredients. The manufacturers start with plant protein – mostly soy for Impossible, pea for Beyond, and potato, oat or equivalent proteins for others – and add carefully selected ingredients to simulate meat-like qualities. Most include coconut oil for its resemblance to the mouthfeel of animal fats, and yeast extract or other flavorings to add meaty flavors. Impossible even adds a plant-derived version of heme, a protein found in animal blood, to yield an even more meat-like appearance and flavor.
All this requires significant processing, notes William Aimutis, a food protein chemist at North Carolina State University, who wrote about plant-based proteins in the 2022 Annual Review of Food Science and Technology. Soybeans, for example, are typically first milled into flour, and then the oils are removed. The proteins are isolated and concentrated, then pasteurised and spray-dried to yield the relatively pure protein for the final formulation. Every step consumes energy, which raises the question: With all this processing, are these meat alternatives really greener than what they seek to replace?
To answer that question, environmental scientists conduct what’s known as a life cycle analysis. This involves taking each ingredient in the final product – soy protein, coconut oil, heme and so forth – and tracing it back to its origin, logging all the environmental costs involved. In the case of soy protein, for example, the life cycle analysis would include the fossil fuels, water and land needed to grow the soybeans, including fossil fuel emissions from the fertiliser, pesticides and transportation to the processing plant. Then it would add the energy and water consumed in milling, defatting, protein extraction and drying.
Similar calculations would apply to all the other ingredients, and to the final process of assembly and packaging. Put it all together, and you end up with an estimate of the total environmental footprint of the product.
Unfortunately, not all those numbers are readily available. For many products, especially unique ones like the new generation of plant-based meats, product details are secrets closely held by the companies involved. “They will know how much energy they use and where they get their fat and protein from, but they will not disclose that to the general public,” says Ricardo San Martin, a chemical engineer who codirects the Alternative Meats Lab at the University of California, Berkeley. As a result, most life cycle analyses of plant-based meat products have been commissioned by the companies themselves, including both Beyond and Impossible. Outsiders have little way of independently verifying them.
Even so, those analyses suggest that plant-based meats offer clear environmental advantages over their animal-based equivalents. Impossible’s burger, for example, causes just 11% of the greenhouse gas emissions that would come from an equivalent amount of beef burger, according to a study the company commissioned from the sustainability consulting firm Quantis. Beyond’s life cycle analysis, conducted by researchers at the University of Michigan, found their burger’s greenhouse gas emissions were 10% of those of real beef.
Indeed, when independent researchers at Johns Hopkins University decided to get the best estimates they could by combing through the published literature, they found that in the 11 life cycle analyses they turned up, the average greenhouse gas footprint from plant-based meats was just 7% of beef for an equivalent amount of protein. The plant-based products were also more climate-friendly than pork or chicken – although less strikingly so, with greenhouse gas emissions just 37% and 57%, respectively, of those for the actual meats.
Similarly, the Hopkins team found that producing plant-based meats used less water: 23% that of beef, 11% that of pork and 24% that of chicken for the same amount of protein. There were big savings, too, for land, with the plant-based products using 2% that of beef, 18% that of pork and 23% that of chicken for a given amount of protein. The saving of land is important because, if plant-based meats end up claiming a significant market share, the surplus land could be allowed to revert to forest or other natural vegetation; these store carbon dioxide from the atmosphere and contribute to biodiversity conservation. Other studies show that plant-based milks offer similar environmental benefits over cow’s milk (see Box).
A caution on cultivation methods
Of course, how green plant-based meats actually are depends on the farming practices that underlie them. (The same is true for meat itself – the greenhouse gas emissions generated by a pound of beef can vary more than tenfold from the most efficient producers to the least.) Plant-based ingredients such as palm oil grown in plantations that used to be rainforest, or heavily irrigated crops grown in arid regions, cause much more damage than more sustainably raised crops. And cultivation of soybeans, an important ingredient for some plant-based meats, is a major contributor to Amazon deforestation.
However, for most ingredients it seems likely that even poorly produced plant-based meats are better, environmentally, than meat from well-raised livestock. Plant-based meats need much less soy than would be fed to actual livestock, notes Matin Qaim, an agricultural economist at the University of Bonn, Germany, who wrote about meat and sustainability in the 2022 Annual Review of Resource Economics. “The reason we’re seeing deforestation in the Amazon,” he explains, “is because the demand for food and feed is growing. When we move away from meat and more toward plant-based diets, we need less area in total, and the soybeans don’t necessarily have to grow in the Amazon.”
But green as they are, plant-based meats have a few hurdles to clear before they can hope to replace meat. For one thing, plant-based meats currently cost an average of 43% more than the products they hope to replace, according to the Good Food Institute. That helps to explain why plant-based meats account for less than 1% of meat sales in the US. Advocates are optimistic that the price will come down as the market develops, but it hasn’t happened yet. And achieving those economies of scale will take a lot of work: Even growing to a mere 6% of the market will require a $27 billion investment in new facilities, says Swartz.
Steak hasn’t yet been well done
In addition, all of today’s plant-based meats seek to replace ground-meat products like burgers and chicken nuggets. Whole-muscle meats like steak or chicken breast have a more complex, fibrous structure that the alt-meat companies have not yet managed to mimic outside the lab.
Part of the problem is that most plant proteins are globular in shape, while real muscle proteins tend to form long fibers. To form a textured meat-like product, scientists essentially have to turn golf balls into string, says David Julian McClements, a food scientist at the University of Massachusetts, Amherst, and an editor of the Annual Review of Food Science and Technology. There are ways to do that, often involving high-pressure extrusion or other complex technology, but so far no one has a whole-muscle product ready for market. (A fungal product, sold for decades in some countries as Quorn, is naturally fibrous, but its sales have never taken off in the US. Other companies are also working on meat substitutes based on fungal proteins.)
McClements is experimenting with another approach to make plant-based bacon: creating separate plant-based analogs of muscle and fat, then 3D-printing the distinctive marbling of the bacon. “I think we’ve got all the elements to put it together,” he says.
Some critics also note that a shift toward plant-based meat may reinforce the industrialisation of global food systems in an undesirable way. Most alternative meat products are formulated in factories, and their demand for plant proteins and other ingredients favors Big Agriculture, with its well-documented problems of monoculture, pesticide use, soil erosion and water pollution from fertiliser runoff. Plant-based meats will reduce the impact of these unsustainable farming practices, but they won’t eliminate them unless current farming practices change substantially.
Of course, all the to-do about alternative meats overlooks another dietary option, one with the lowest environmental footprint of all: Simply eat less meat and more beans, grains and vegetables. The additional processing involved in plant-based meats means that they generate 4.6 times more greenhouse gas than beans, and seven times more than peas, per unit of protein, according to the Hopkins researchers. Even traditional, minimally processed plant protein such as tofu beats plant-based meats when it comes to greenhouse gas. Moreover, most people in wealthy countries eat far more protein than they need, so they can simply cut back on their protein consumption without seeking out a replacement.
But that option may not appeal to the meat-eating majority today, which makes alternative meats a useful stopgap. “Would I prefer that people were eating beans and grains and tofu, and lots of fruits and vegetables? Yes,” says Bonnie Liebman, director of nutrition at the Centre for Science in the Public Interest, an advocacy organisation supporting healthy eating.
“But there are a lot of people who enjoy the taste of meat and are probably not going to be won over by tofu. If you can win them over with Beyond Meat, and that helps reduce climate change, I’m all for it.”
Aside: Plant-based milks – Meat isn’t the only source of animal protein with a high environmental cost. Dairy, too, causes large emissions of greenhouse gas from cud-chewing cows and sheep, and from growing feed. Here, too, plant-based alternatives, many of which are already mainstream options in the grocery store, may be an environmentally friendlier alternative – in some ways, at least.
Just how much friendlier they are, though, depends on how you measure their footprint. One option is to express environmental costs per quart of milk. By that measure, all plant-based milks shine. Soy milk, for example, requires just 7% as much land and 4% as much water as real milk, while emitting only 31% as much greenhouse gas. Oat milk needs 8% of the land and 8% of the water, while releasing just 29% as much greenhouse gas. Even almond milk – often regarded as a poor choice because almond orchards guzzle so much fresh water – uses just 59% as much water as real milk.
But not all plant-based milks deliver the same nutrient punch. While soy milk provides almost the same amount of protein as cow’s milk, almond milk provides only about 20% as much – an important consideration for some. On a per-unit-protein basis, therefore, almond milk actually generates more greenhouse gas and uses more water than cow’s milk.
Note: This article was updated at 9:56 am on September 8, 2022, to correct a transposition of two numbers. Plant-based products have greenhouse emissions just 57% of those for chicken and 37% those for pork.
Bob Holmes is a science writer – and guilty omnivore – based in Edmonton, Canada. This article originally appeared in Knowable Magazine, an independent journalistic endeavor from Annual Reviews.